Articles
All articles | Recent articles
Densification Behavior and Mechanical Properties of Niobium-Oxide-Doped Alumina Ceramics
A.M. Hassan1, M. Awaad2, F. Bondioli3, S.M. Naga2
1 Zagazig Uni., Faculty of Engineering, Materials Engineering Dept, 44519 - Zagazig, Egypt
2 National Research Center, Ceramics Dept, El-Bohous Str., 12622 - Cairo, Egypt
3 Department of Industrial Engineering, Parco delle Scienze 181/A, 43124 - Parma, Italy
received December 10, 2013, received in revised form January 10, 2014, accepted January 24, 2014
Vol. 5, No. 1, Pages 51-56 DOI: 10.4416/JCST2013-00045
Abstract
The densification behavior, microstructure and mechanical properties of high-purity α-Al2O3 doped with 0.25, 0.5 and 0.75 wt% Nb2O5 were investigated. The batches were uniaxially pressed at 220 MPa into discs and rectangular bars and pressureless-sintered at temperature ranging between 1500º and 1650 °C for 1 h. The phase composition of the sintered bodies was followed up with an x-ray diffractometer, while their microstructure was characterized with a scanning electron microscope. The mechanical properties in terms of Vickers hardness (HV1), three-point bending strength and fracture toughness were also measured. The results showed that the addition of Nb2O5 accelerated the densification parameters, reinforced and toughened the obtained bodies. The maximum values for the mechanical properties of the Nb2O5-doped alumina-based ceramics were 34.4, 35.5 and 29.5 % for bending strength, fracture toughness and Vickers hardness respectively, which are higher than those of the undoped and doped technical alumina.
Download Full Article (PDF)
Keywords
Doping, alumina, niobia, microstructure, mechanical properties
References
1 Maiti, K., Sil, A.: Microstructural relationship with fracture toughness of undoped and rare earths (Y, La) doped Al2O3-ZrO2 ceramic composites, Ceram. Int., 37, 2411 – 2421, (2011).
2 Oungkulsolmongkol, T., Salee-Art, P., Buggakupta, W.: Hardness and fracture toughness of alumina-based particulate composites with zirconia and strontia additives, J. Met. Mat. & Min., 20, [2], 71 – 78, (2010).
3 Xihua, Z., Changxia, L., Musen, L., Jianhua, Z.: Research on toughening mechanisms of alumina matrix ceramic composite materials improved by rare earth additive, J. Rare Earths, 26, [3] 367 – 370, (2008).
4 Zhang, X.H., Liu, C.X., Li, M.S., Zhang, J.H., Sun, J.L.: Toughening mechanism of alumina-matrix ceramic composites with the addition of AlTiC master alloys and ZrO2, Ceram. Int., 35, 93 – 97, (2009).
5 Yang, Y., Wang, Y., Tian, W., Wang, Z., Zhao, Y., Wang, L., Bian, H.: Reinforcing and toughening alumina/titania ceramic composites with nano-dopants from nanostructured composite powders, Mat. Sci. & Eng. A, 508, 161 – 166, (2009).
6 Rani, D.A., Yoshizawa, Y., Hirao, K., Yamauchi, Y.: Effect of rare-earth dopants on mechanical properties of alumina, J. Am. Ceram. Soc., 87, [2], 289 – 292, (2004).
7 Galmarini, S., Aschauer, U., Tewari, A., Aman, Y., Van Gestel, C., Bowen, P.: Atomistic modeling of dopant segregation in α-alumina ceramics: coverage dependent energy of segregation and nominal dopant solubility, J. Eur. Ceram. Soc., 31, 2829 – 2852, (2011).
8 West, G.D., Perkins, J.M., Lewis, M.H.: The effect of rare earth dopants on grain boundary cohesion in alumina, J. Eur. Ceram. Soc., 27, 1913 – 1918, (2007).
9 French, J.D.: High temperature deformation and fracture toughness of duplex ceramic microstructures, Ph.D. Thesis Lehigh University, Bethlehem, PA, (1993).
10 Przybylski, K., Garratt-Reed, A.J, Pint, B.A., Katz, E.P., Yurek, G.J.: Segregation of Y to grain boundaries in the Al2O3 scale formed on a ODS alloy, J. Electrochem. Soc., 143, 3207 – 3208, (1987).
11 Gruffel, P., Carry, C.: Effect of grain size on yttrium grain boundary segregation in fine-grained alumina, J. Eur. Ceram. Soc., 11, 189 – 199, (1993).
12 Deng, Z.Y., Zhou, Y., Brito, M.F., Tanaka, Y., Ohji, T.: Effects of rare earth dopants on grain boundary bonding in alumina-silicon carbide composite, J. Eur. Ceram. Soc., 24, 511 – 516, (2004).
13 Acchar, W., Segades, A.M.: Properties of sintered alumina reinforced with niobium carbide critical, Int. J. of Ref. Met. & Hard Mat., 27, 427 – 430, (2009).
14 Zhao, G., Huang, C., Liu, H., Zou, H., Zhu, H., Wang, J.: Preparation of in-situ growth TaC whiskers toughening Al2O3 ceramic matrix composite, Int. J. of Ref. Met. & Hard Mat., 36, 122 – 125, (2013).
15 Chan, H.M., Harmer, M.R.: Effect of Nb2O5 doping on the densification and abnormal grain growth behavior of high-purity alumina, J. Am. Ceram. Soc., 87, [3], 378 – 383, (2004).
16 Anstis, G.R., Chantikul, P., Lawn, B.R., Marshall, D.B.: A critical evaluation of indentation techniques for measuring fracture toughness: I, Direct crack measurement, J. Am. Ceram. Soc., 64, 533 – 538, (1981).
17 Tang, D., Lim, H., Lee, K., Lee, C., Cho, W.: Evaluation of mechanical reliability of zirconia-toughened alumina composites for dental implants, Ceram. Int., 38, 2429 – 2436, (2012).
18 Prüfung von keramischen Hochleistungswerkstoffen, Ermittlung der Risszähigkeit KIc (Testing high-performance ceramic materials, determination of the fracture toughness, KIc, in German), Berlin, Beuth-Verlag, (1991).
19 Munz. D., Fett, T.: Ceramics: mechanical properties, failure behaviour, materials selection, Berlin, Springer-Verlag, (1999).
20 Fang, J., Thompson, A.M., Harmer, M.P., Chan, H.M.: Effect of yttrium and lanthanum on the final-stage sintering behavior of ultrahigh-purity alumina, J. Am. Ceram. Soc., 80, [8], (1997), 2005 – 2012.
21 Wang, C-M., Chan, H.M., Harmer, M.P.: Effect of Nd2O3 doping on the densification and abnormal grain growth behavior of high-purity alumina, J. Am. Ceram. Soc., 87, [3], (2004), 378 – 383.
22 Yamagguchi, O., Tomihisa, D., Shimizu, K.: Formation and transformation of δ- Nb2O5 solid solutions in the system Nb2O5 -Al2O3, Z. Anorg. Allg. Chem., 569, 177 – 182, (1989).
23 Muller, E.K., Nicholson, B.J.: Concerning the phase diagram and dielectric behavior of the oxide system Al2O3- Nb2O5, J. Am. Ceram. Soc., 45, [5], 250 – 251, (1962).
24 Pedersen, B.F.: The crystal structure of aluminum niobium oxide (AlNbO4), Acta. Chem. Scand., 16, 421 – 430, (1962).
25 Chonghai, X., Chuanzhen, H., Xing, A.: Toughening and strengthening of advanced ceramics with rare earth additives, Ceram. Int., 32, 423 – 429, (2006).
26 Riu, D., Min Kong, Y., Kim, H. E.: Effect of Cr2O3 addition on microstructural evolution and mechanical properties of Al2O3, J. Eur. Ceram. Soc., 20, 1475 – 1481, (2000).
Copyright
Göller Verlag GmbH